ACC Maintainers Expedite A-10 Inspection Actions

LANGLEY AIR FORCE BASE: Air Combat Command maintenance Airmen will begin an immediate inspection of all A-10 Thunderbolt II aircraft with thin-skinned wings for cracking following a Time Compliance Technical Order issued to ACC A-10 units on Oct. 3.

ACC officials are working closely with those in Air Force Materiel Command and other combat Air Force major commands to address all of the thin-skin winged A-10s with a priority focus being the A-10s currently in the U.S. Central Command area of responsibility.

There are later models of the A-10 that have thicker-skinned wings.

"The TCTO was released very early this morning and ACC maintainers have been actively complying with the requirements of that TCTO," said Lt. Col. David Trucksa, ACC A3 chief of flight management, "and the jets that were affected were pulled off the schedule and they are not flying as the maintainers are setting up their inspections and pressing forward."

Air Force flying and combat operations are inherently dangerous, ACC officials said. Aircrew and maintenance personnel mitigate risk by continuously applying Operational Risk Management principles.

"ACC maintainers will never provide an airplane to a pilot that is known to be unsafe," said Colonel Trucksa. "It will meet all safety standards."

Because of intense cross-checking of maintenance operations, Colonel Trucksa said he has full confidence in the inspection process.

Air Combat Command has 56 A-10 aircraft affected by this AFMC-issued TCTO. This risk is of great concern to ACC officials and is representative of a systemic problem of an aging Air Force fleet, they say.

"The airframe is 28 years old on average," said Major David Ruth from the ACC A-10 Weapons System Team. "Every weapons system has fatigue of some type. It's just a matter of identifying it ahead of time and mitigating that through scheduled depot inspections and maintenance."

As the aircraft are getting older, they will have different problems in different areas, said Colonel Trucksa. "It's just a concern if the jet doesn't meet the standards of safety," he said.

ACC A-10s will not be cleared for operational status until they have been inspected and any discrepancies found have been repaired or cleared. Command maintenance planners will work with AFMC experts on a timeline for repairs.

The location, size and orientation of cracks identified will determine the length of time aircraft are down.

After engineers analyzed data, they determined the number of flight hours it took for the wing to suffer critical crack length.

"They apply a safety factor that basically guides them in developing the TCTO," said Major Ruth. "This drives the current 450 flight hours in the current TCTO."

Depot personnel who were working on a repair regarding the A-10's thick-skin fleet identified the cracks on the thin-skin aircraft that drove the depot to evaluate crack criticality and identification of the thin-skin aircraft that are affected.

"For the thin-skin fleet, they did fatigue testing over the years," said Major Ruth. "We are programmed to replace the thin-skins beginning in fiscal year 2010 through FY 2016. We already have contracts to replace those."

To maintain combat readiness and support, ACC maintainers are working diligently with inspection data to minimize the impact this critical ground support aircraft provides to the warfighter.

"Right now we are looking at courses of action," said Major Ruth. "We do have some capability within the mission design series, within the A-10 fleet to meet AOR commitments."

Major Ruth explained that ACC officials are determining the proper courses of action needed to keep the A-10 combat ready for USCENTCOM requirements.